GHS Classification Result

Chemical Name:Hexanal
CAS:66-25-1

Result:
ID: 21A3584
Classifier: Ministry of Health, Labour and Welfare (MHLW), Ministry of the Environment (MOE)
Year Classified: FY2009
Reference Manual: GHS Classification Guidance by the Japanese Government (March, 2009)

PHYSICAL HAZARDS
Hazard class Classification Symbol Signal word Hazard statement Precautionary statement Rationale for the classification
1 Explosives Not applicable - - - - There are no chemical groups associated with explosive properties present in the molecules.
2 Flammable gases (including chemically unstable gases) Not applicable - - - - Liquid (GHS definition)
3 Aerosols Not applicable - - - - Not aerosol products.
4 Oxidizing gases Not applicable - - - - Liquid (GHS definition)
5 Gases under pressure Not applicable - - - - Liquid (GHS definition)
6 Flammable liquids Category 3 Warning H226: Flammable liquid and vapour P303+P361+P353: IF ON SKIN (or hair): Remove/Take off immediately all contaminated clothing. Rinse skin with water/shower.
P370+P378: In case of fire: Use ... for extinction.
P403+P235: Store in a well-ventilated place. Keep cool.
P210: Keep away from heat/sparks/open flames/hot surfaces. - No smoking.
P233: Keep container tightly closed.
P240: Ground/bond container and receiving equipment.
P241: Use explosion-proof electrical/ventilating/lighting/.../equipment.
P242: Use only non-sparking tools.
P243: Take precautionary measures against static discharge.
P280: Wear protective gloves/protective clothing/eye protection/face protection.
P501: Dispose of contents/container to ...
Classified into Category 3 since flash point 32 degC (open-cup) (Sax (11th, 2004)) is >=23 degC and <=60 degC, further the substance is classified into Class 3, PG III in UNRTDG (UN1207).
7 Flammable solids Not applicable - - - - Liquid (GHS definition)
8 Self-reactive substances and mixtures Not applicable - - - - There are no chemical groups present in the molecule associated with explosive or self-reactive properties.
9 Pyrophoric liquids Not classified - - - - Auto-ignition point is approximately 220 degC (Hommel (1996)) exceeding 70 degC.
10 Pyrophoric solids Not applicable - - - - Liquid (GHS definition)
11 Self-heating substances and mixtures Classification not possible - - - - Test methods applicable to liquid substances are not available.
12 Substances and mixtures which, in contact with water, emit flammable gases Not applicable - - - - The chemical structure of the substance does not contain metals or metalloids (B, Si, P, Ge, As, Se, Sn, Sb, Te, Bi, Po, At).
13 Oxidizing liquids Not applicable - - - - The substance is an organic compound containing oxygen (but not fluorine or chlorine) which is chemically bonded only to carbon.
14 Oxidizing solids Not applicable - - - - Liquid (GHS definition)
15 Organic peroxides Not applicable - - - - Organic compounds containing no bivalent -O-O- structure
16 Corrosive to metals Classification not possible - - - - No data available.

HEALTH HAZARDS
Hazard class Classification Symbol Signal word Hazard statement Precautionary statement Rationale for the classification
1 Acute toxicity (Oral) Not classified - - - - Based on a LD50 value of 4.9 g/kg for rats (HSDB (2009)), the substance was classified into "Not classified" in JIS Classification (correspond to Category 5 in GHS classification).
1 Acute toxicity (Dermal) Classification not possible - - - - No data available.
1 Acute toxicity (Inhalation: Gases) Not applicable - - - - Liquid (GHS definition)
1 Acute toxicity (Inhalation: Vapours) Classification not possible - - - - Classification not possible due to lack of data. As relevant information, there are reports that inhalation exposure to rats at 2000 ppm for 4-hour resulted in mortality of 1/6 and inhalation to rats at the concentrated vapour for 1-hour resulted in mortality of 0/6 (HSDB (2009)).
1 Acute toxicity (Inhalation: Dusts and mists) Classification not possible - - - - No data available.
2 Skin corrosion/irritation Category 2 Warning H315: Causes skin irritation P302+P352: IF ON SKIN: Wash with plenty of soap and water.
P332+P313: If skin irritation occurs: Get medical advice/attention.
P264: Wash ... thoroughly after handling.
P280: Wear protective gloves/protective clothing/eye protection/face protection.
P321: Specific treatment (see ... on this label).
P362: Take off contaminated clothing and wash before reuse.
Based on reports that the substance is "irritant" (PATTY (5th, 2001)) and "irritating" for the skin (HSDB (2003)), the substance was classified into Category 2. As relevant information, there is a result of "mild" irritating in a standard Draize test where 500 mg was applied to the skin of rabbits for 24-hour (RTECS (2008)).
3 Serious eye damage/eye irritation Category 2A Warning H319: Causes serious eye irritation P305+P351+P338: IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing.
P337+P313: If eye irritation persists: Get medical advice/attention.
P264: Wash ... thoroughly after handling.
P280: Wear protective gloves/protective clothing/eye protection/face protection.
Based on results of "moderate irritation" in a rabbit test (PATTY (5th, 2001)) and grade 5 irritation (the most severe injury; grade 10) in another rabbit test (HSDB (2009)), the substance was classified into Category 2A.
4 Respiratory sensitization Classification not possible - - - - No data available.
4 Skin sensitization Classification not possible - - - - No data available.
5 Germ cell mutagenicity Classification not possible - - - - Classification not possible due to lack of data from in vivo mutagenicity tests. From in vitro mutagenicity tests, there are reports of a positive bacterial mutagenicity test and a positive Chinese hamster lung cells (V79 cells) mutagenicity test (PATTY (5th, 2001)).
6 Carcinogenicity Classification not possible - - - - No data available.
7 Reproductive toxicity Classification not possible - - - - No data available.
8 Specific target organ toxicity - Single exposure Category 3 (Respiratory tract irritation) Warning H335: May cause respiratory irritation (respiratory tract irritation) P304+P340: IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for breathing.
P403+P233: Store in a well-ventilated place. Keep container tightly closed.
P261: Avoid breathing dust/fume/gas/mist/vapours/spray.
P271: Use only outdoors or in a well-ventilated area.
P312: Call a POISON CENTER or doctor/physician if you feel unwell.
P405: Store locked up.
P501: Dispose of contents/container to ...
The substance is irritant (PATTY (5th, 2001)) and vapour is irritating to nose and throat (HSDB (2003)). Additionally, it is reported that the low molecular weight aldehydes, the halogenated aliphatic aldehydes, and the unsaturated aldehydes are particularly irritating, The mucus membranes of the nasal and oral passages and the upper respiratory tract are affected, producing a burning sensation, an increased ventilation rate, bronchial constriction, choking, and coughing (HSDB (2003)). Based these information, the substance was classified into Category 3 (respiratory tract irritation).
9 Specific target organ toxicity - Repeated exposure Classification not possible - - - - No data available.
10 Aspiration hazard Classification not possible - - - - No data available.

ENVIRONMENTAL HAZARDS
Hazard class Classification Symbol Signal word Hazard statement Precautionary statement Rationale for the classification
11 Hazardous to the aquatic environment (Acute) Category 3 - - H402: Harmful to aquatic life P273: Avoid release to the environment.
P501: Dispose of contents/container to ...
Classified into Category 3 from its 96h-LC50 = 14 mg/L for fish (Fathead minnow) (AQUIRE, 2010; HSDB, 2009).
11 Hazardous to the aquatic environment (Long-term) Category 3 - - H412: Harmful to aquatic life with long lasting effects P273: Avoid release to the environment.
P501: Dispose of contents/container to ...
Classified into Category 3 since its acute toxicity is Category 3, BOD degradation rate = 50% at 4 weeks and it is not rapidly degradable (Biodegradation and Bioconcentration of Existing Chemical Substances under the Chemical Substances Control Law, 2002).


NOTE:
* Classification was conducted by relevant Japanese Ministries in accordance with GHS Classification Guidance for the Japanese Government, and is intended to provide a reference for preparing GHS labelling and SDS for users.
* This is a provisional English translation of classification results and is subject to revision without notice.
* The responsibility for any resulting GHS labelling and SDS referenced from this site is with users.

Reference:
Reference Manual

Definitions / Abbreviations

Model Label by MHLW

MHLW Website (in Japanese Only)

Model SDS by MHLW

MHLW Website (in Japanese Only)


To GHS Information