GHS Classification Result

Chemical Name:tert-Butylamine
CAS:75-64-9

Result:
ID: 22A4140
Classifier: Ministry of Health, Labour and Welfare (MHLW), Ministry of the Environment (MOE)
Year Classified: FY2010
Reference Manual: GHS Classification Guidance by the Japanese Government (July, 2010)

PHYSICAL HAZARDS
Hazard class Classification Symbol Signal word Hazard statement Precautionary statement Rationale for the classification
1 Explosives Not applicable - - - - There are no chemical groups associated with explosive properties present in the molecule.
2 Flammable gases (including chemically unstable gases) Not applicable - - - - Liquid (GHS definition)
3 Aerosols Not applicable - - - - Not aerosol products.
4 Oxidizing gases Not applicable - - - - Liquid (GHS definition)
5 Gases under pressure Not applicable - - - - Liquid (GHS definition)
6 Flammable liquids Category 2 Danger H225: Highly flammable liquid and vapour P303+P361+P353: IF ON SKIN (or hair): Remove/Take off immediately all contaminated clothing. Rinse skin with water/shower.
P370+P378: In case of fire: Use ... for extinction.
P403+P235: Store in a well-ventilated place. Keep cool.
P210: Keep away from heat/sparks/open flames/hot surfaces. - No smoking.
P233: Keep container tightly closed.
P240: Ground/bond container and receiving equipment.
P241: Use explosion-proof electrical/ventilating/lighting/.../equipment.
P242: Use only non-sparking tools.
P243: Take precautionary measures against static discharge.
P280: Wear protective gloves/protective clothing/eye protection/face protection.
P501: Dispose of contents/container to ...
Since its flash point reported -8 degC (closed-cup) (NFPA (13th, 2006)) is < 23 degC, and initial boiling point reported < 44.04 degC (Lide (90th, 2009)) is > 35 degC, the substance corresponds to Category 2.
7 Flammable solids Not applicable - - - - Liquid (GHS definition)
8 Self-reactive substances and mixtures Not applicable - - - - There are no chemical groups present in the molecule associated with explosive or self-reactive properties.
9 Pyrophoric liquids Not classified - - - - Since its autoignition temperature is 380 degC (NFPA (13th, 2006)), it is considered that the substance does not ignite at room temperature.
10 Pyrophoric solids Not applicable - - - - Liquid (GHS definition)
11 Self-heating substances and mixtures Classification not possible - - - - Test methods applicable to liquid substances are not available.
12 Substances and mixtures which, in contact with water, emit flammable gases Not applicable - - - - The chemical structure of the substance does not contain metals or metalloids (B, Si, P, Ge, As, Se, Sn, Sb, Te, Bi, Po, At).
13 Oxidizing liquids Not applicable - - - - Organic compounds containing no oxygen, fluorine or chlorine.
14 Oxidizing solids Not applicable - - - - Liquid (GHS definition)
15 Organic peroxides Not applicable - - - - Organic compounds containing no bivalent -O-O- structure.
16 Corrosive to metals Classification not possible - - - - Test methods applicable to liquid substance of low-boiling point are not available.

HEALTH HAZARDS
Hazard class Classification Symbol Signal word Hazard statement Precautionary statement Rationale for the classification
1 Acute toxicity (Oral) Category 3 Danger H301: Toxic if swallowed P301+P310: IF SWALLOWED: Immediately call a POISON CENTER or doctor/physician.
P264: Wash ... thoroughly after handling.
P270: Do not eat, drink or smoke when using this product.
P321: Specific treatment (see ... on this label).
P330: Rinse mouth.
P405: Store locked up.
P501: Dispose of contents/container to ...
Based on the rat LD50 value of 80 mg/kg (PATTY, 5th (2001)), the substance was classified as Category 3.
1 Acute toxicity (Dermal) Not classified - - - - Based on the rabbit LDLo value of 2 gm/kg (RTECS (2008), original literature: National Technical Information Service. OTS0570521), the substance was classified as "Not classified" in the JIS classification (corresponding to Category 5 or "Not classified" in the UN-GHS classification).
1 Acute toxicity (Inhalation: Gases) Not applicable - - - - Liquid (GHS definition)
1 Acute toxicity (Inhalation: Vapours) Category 3 Danger H331: Toxic if inhaled P304+P340: IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for breathing.
P403+P233: Store in a well-ventilated place. Keep container tightly closed.
P261: Avoid breathing dust/fume/gas/mist/vapours/spray.
P271: Use only outdoors or in a well-ventilated area.
P311: Call a POISON CENTER or doctor/physician.
P321: Specific treatment (see ... on this label).
P405: Store locked up.
Based on the rat LC50 value of 3.8 mg/L (1270 ppmV) (RTECS (2008), original literature: National Technical Information Service. OTS0570798), the substance was classified as Category 3. The toxic value (3.8 mg/L) was lower than 90% of saturated vapor pressure concentration (1464 mg/L), the criterion values for gas were adopted.
1 Acute toxicity (Inhalation: Dusts and mists) Classification not possible - - - - No data available.
2 Skin corrosion/irritation Classification not possible - - - - No data were available. As relevant notes, skin irritating effects of the substance was reported (HSDB (2008)).
3 Serious eye damage/eye irritation Classification not possible - - - - No data were available. As relevant notes, eye irritating effects of the substance was reported (HSDB (2008)). Exposure to tertiary amines was associated with visual disturbances resulted from edema of the cornea (HSDB (2008)).
4 Respiratory sensitization Classification not possible - - - - No data available.
4 Skin sensitization Classification not possible - - - - No data available.
5 Germ cell mutagenicity Classification not possible - - - - The classification was not possible due to lack of in vivo test data. As relevant information, as for in vitro studies, negative results in the Ames test (NTP DB (Access on Aug. 2010), Mutagenicity Test Data of Existing Chemical Substances based on the toxicity investigation system of the Industrial Safety and Health Law (Supplement 2nd (2000)) were reported.
6 Carcinogenicity Classification not possible - - - - No data available.
7 Reproductive toxicity Classification not possible - - - - No data available.
8 Specific target organ toxicity - Single exposure Classification not possible - - - - No data available.
9 Specific target organ toxicity - Repeated exposure Classification not possible - - - - No data available.
10 Aspiration hazard Classification not possible - - - - No data available.

ENVIRONMENTAL HAZARDS
Hazard class Classification Symbol Signal word Hazard statement Precautionary statement Rationale for the classification
11 Hazardous to the aquatic environment (Acute) Category 3 - - H402: Harmful to aquatic life P273: Avoid release to the environment.
P501: Dispose of contents/container to ...
Classified into Category 3 from its 96h-EC50 = 16 mg/L for algae (Pseudokirchneriella subcapitata) (AQUIRE, 2011).
11 Hazardous to the aquatic environment (Long-term) Category 3 - - H412: Harmful to aquatic life with long lasting effects P273: Avoid release to the environment.
P501: Dispose of contents/container to ...
Classified into Category 3 since its acute toxicity is Category 3 and it is not rapidly degradable (Non-biodegradable, BOD degradation rate: 0% (Biodegradation and Bioconcentration of Existing Chemical Substances under the Chemical Substances Control Law, 2002)).
12 Hazardous to the ozone layer Classification not possible - - - - This substance is not listed in Annexes to the Montreal Protocol.


NOTE:
* Classification was conducted by relevant Japanese Ministries in accordance with GHS Classification Guidance for the Japanese Government, and is intended to provide a reference for preparing GHS labelling and SDS for users.
* This is a provisional English translation of classification results and is subject to revision without notice.
* The responsibility for any resulting GHS labelling and SDS referenced from this site is with users.

Reference:
Reference Manual

Definitions / Abbreviations

Model Label by MHLW

MHLW Website (in Japanese Only)

Model SDS by MHLW

MHLW Website (in Japanese Only)


To GHS Information